環氧地坪的施工注意事項很多，畢竟要達到理想的結果，就喲啊注意許多小細節，所以如果在冬季進行無錫環氧地坪施工，就更加要注意了，這些最好在是施工前就要有所考慮。那么，冬季環氧地坪施工時要注意什么問題呢？施工前需要考慮什么因素呢？冬季無錫環氧地坪的施工注意：

There are many matters needing attention in the construction of epoxy flooring. After all, in order to achieve the desired results, we should pay attention to many small details. Therefore, if we carry out the construction of epoxy flooring in winter, we should pay more attention to them, which should be considered before the construction. So, what problems should we pay attention to during the construction of epoxy flooring in winter? What factors should be considered before construction? Attention should be paid to the construction of epoxy floor in winter. 1、減慢涂料反應，雙組分的環氧地坪涂料施工，需要現場將甲、乙組分按比例混合，攪拌均勻，讓雙組分充分反應，這樣才能保證環氧地坪的效果。但如果溫度低于5℃，反應將會降低或減緩，這會嚴重影響地坪涂料的固化性能。

1. Slow down the reaction of the coating and the construction of the two-component floor coating. It is necessary to mix the A and B components proportionally on the spot, mix evenly, and make the two components react fully, so as to ensure the effect of the floor. However, if the temperature is lower than 5 C, the reaction will be reduced or slowed down, which will seriously affect the curing performance of floor coatings.

2、黏度成倍增長，無溶劑的自流平涂料靠流平性保證地坪的平整度。但低溫下，地坪涂料的黏度會成倍增加，流平性能將降低。而不靠流平性的涂料，刮涂時會因為流動、流平性能變差，而出現鏝刀痕的缺陷。

2. Viscosity increases exponentially. Solvent-free self-leveling coating guarantees the leveling of the floor by leveling. However, at low temperatures, the viscosity of floor coatings will be doubled and the leveling performance will be reduced. However, without leveling coating, the defect of trowel marks will appear when scratching because of the poor flow and leveling performance.

3、降低涂膜質量，由于固化反應減慢，或者完成不能固化，涂膜的強度、硬度、耐磨性都將會降低，而且會更容易出現地坪脫離等問題，嚴重的影響環氧地坪的使用壽命。

3. To reduce the quality of the coating, the strength, hardness and wear resistance of the coating will be reduced due to the slow curing reaction or the failure of curing, and it will be more prone to problems such as floor detachment, which will seriously affect the service life of the epoxy floor.

4、冬季環氧地坪施工，最好在室內施工，室內溫度相對于室外溫度較高，比較容易撐控，如：打開暖氣等設備增加室內溫度，從而達到施工良好效果。

4. The construction of epoxy floor in winter is better in indoor construction. The indoor temperature is higher than the outdoor temperature. It is easier to support and control. For example, opening the heating and other equipment to increase the indoor temperature, so as to achieve good construction results.

5、冬季環氧地坪漆施工，為了解決環氧地坪漆在低溫下黏度大，缺乏流動性難攪拌，可添加小于5%的揮發速率較快的3溶劑。

5. During the construction of epoxy floor paint in winter, in order to solve the problem that epoxy floor paint has high viscosity at low temperature and lacks fluidity and is difficult to mix, 3 solvents with a faster volatilization rate of less than 5% can be added.

6、冬季環氧地坪漆施工，由于氣漫低下所造成，以至于環氧地坪漆施工的間隔需要延長，要確定漆已經干透才能施工第二道漆。

6. During the construction of epoxy floor paint in winter, the air diffuse is so low that the construction interval of epoxy floor paint needs to be extended. It is necessary to make sure that the paint has been dried thoroughly before the second paint can be constructed.

7、冬季環氧地坪漆施工時，一定要避開低溫時段，最好在白天的上午10點至下午3點內施工，低溫時段停止施工，減少低溫對環氧地坪漆施工質量的影響。

7. During the construction of epoxy floor paint in winter, it is necessary to avoid the low temperature period. It is better to construct the epoxy floor paint in the daytime from 10 a.m. to 3 p.m. and stop the construction in the low temperature period so as to reduce the influence of low temperature on the construction quality of epoxy floor paint.

8、冬季環氧地坪施工中，每道地坪漆的厚薄度一定要掌控好，不要過于厚，越厚越難干。

8. In the construction of epoxy floor in winter, the thickness of each floor paint must be well controlled, not too thick, the thicker the harder to dry.

環氧地坪施工前要考慮的因素：

The factors to be considered before construction of epoxy floor are as follows:

1、地面是否滿足環氧地坪漆施工條件

1. Whether the ground meets the construction conditions of epoxy floor paint

有些地方并不是你覺的可以施工環氧地坪漆就能施工的，前期需要地坪漆廠家經過地面勘測，檢測地面的含水率、平整度、現有地面的強度硬度等。對于地面含水率高于6%的要進行排水處理，平整度不夠的需要打磨處理，起砂起灰非常嚴重的則建議重新做混凝土，然后才能施工環氧地坪漆。

Some places are not what you think can be constructed epoxy floor paint can be constructed, early need floor paint manufacturers through ground survey, testing the moisture content of the ground, smoothness, strength and hardness of the existing ground. For surface water content higher than 6%, drainage treatment should be carried out, flatness is not enough to need polishing treatment, sand and ashing is very serious, it is suggested that concrete be made again, and then epoxy floor paint can be constructed.

2、是否能用環氧地坪漆

2. Can epoxy floor paint be used?

對于可以使用環氧地坪漆的地面要選擇使用適合的地坪材料，選擇合適的可以避免很多外在因素。環氧地坪漆廠家建議對于要求潔凈程度高的場合可以選擇環氧自流平地坪。

For the ground which can use epoxy floor paint, we should choose the suitable floor material and choose the suitable floor material, which can avoid many external factors. The epoxy floor paint manufacturer suggests that the epoxy self-leveling floor can be chosen for the occasions requiring high cleanliness.

對地面只是要求防塵走人的可以選擇經濟實用的環氧平涂地坪，對地面要求耐磨抗壓且有叉車行走的建議選擇環氧砂漿地坪，要是要求具備防靜電的就可以使用環氧防靜電地坪。

For the ground, only the economical and practical epoxy flat-coated floor is required. For the ground, the suggestion of wear-resisting and pressure-resisting and forklift walking is to choose the epoxy mortar floor. If the anti-static floor is required, the anti-static epoxy floor can be used.

3、現場環境是否滿足施工要求

3. Whether the site environment meets the construction requirements

使用環氧地坪涂料施工完成需要時間固化成型，所以對溫度濕度都有嚴格要求，溫度過高過低，濕度過大等情況都要適當的延緩施工，避免因這個問題而導致地坪質量問題，切記不可在溫度濕度條件不允許的情況為了趕工期硬要施工。

It takes time to solidify and form the epoxy floor coatings, so there are strict requirements for temperature and humidity. If the temperature is too high or too low, and the humidity is too high, the construction should be delayed properly, so as to avoid the quality problems caused by this problem. Keep in mind that the conditions of temperature and humidity are not allowed, in order to catch up with the construction period. Construction is needed.

另外，施工現場需要做好封閉管理，避免灰塵雜物落在漆膜表面，影響環氧地坪漆施工效果。

In addition, the construction site needs to do a good job of closed management, to avoid dust and sundries falling on the surface of the paint film, affecting the construction effect of epoxy floor paint.

4、做完環氧地坪漆后的養護工作

4. Maintenance after finishing epoxy floor paint

做完無錫環氧地坪漆后一般不能立即投入使用，需要養護7天，在養護期間，應避免水或其它溶液浸潤表面。

After finishing the epoxy floor paint, it can not be put into use immediately. It needs to be maintained for 7 days. During the maintenance period, water or other solution should be avoided to infiltrate the surface.